Error P0599 on JAC все модели
Thermostat Heater Control Circuit High
Code
P0599
Vehicle
JAC все модели
Category
Powertrain
Severity
⚠️ MediumSymptoms
- Check Engine light is on
- The engine runs at a reduced operating temperature
- Increased fuel consumption, especially in winter
- Poor interior heating
- Coolant temperature sensor shows low values
Causes
- Short circuit of the thermostat heater control wire to power (+12 V)
- Broken feedback wire or thermostat ground
- Internal thermostat fault (always open)
- Damage to wiring insulation
- ECU malfunction (rare)
How to Fix
- Read error codes and check for additional temperature-related codes
- Inspect the thermostat connector and wiring for damage and melting.
- Check the voltage in the control circuit with the ignition on and the engine running.
- Check the insulation of the control wire for short circuit with power (+12 V)
- Measure the resistance of the thermostat heating element
- If the malfunction is confirmed, replace the thermostat assembly
- Reset error codes and perform a diagnostic test drive
FAQ
Чем P0599 отличается от P0598?
P0598 — низкий уровень напряжения (обычно замыкание на массу), P0599 — высокий уровень (замыкание на питание или обрыв). Оба кода указывают на неисправность цепи нагревателя термостата.
Повлияет ли P0599 на расход топлива?
Да. При постоянно открытом термостате двигатель работает при слишком низкой температуре, топливо сгорает хуже, расход может вырасти на 5–10%.
Насколько сложно заменить управляемый термостат?
Замена управляемого термостата аналогична обычному: слить антифриз, отсоединить патрубки и разъём, установить новый термостат. Работа занимает 1–2 часа.