Error P05AD on Chery все модели
Active Grille Air Shutter B Position Sensor Circuit Intermittent
Code
P05AD
Vehicle
Chery все модели
Category
Powertrain
Severity
✅ LowSymptoms
- Check Engine light comes on, sometimes goes out on its own
- Unpredictable position of the grille blinds
- Intermittent decrease in fuel efficiency
- The error appears only under certain conditions (frost, heat, vibration)
- Difficulty in reproducing a fault during diagnostics
Causes
- Damaged wiring with periodic breaks (insulation cracks)
- Oxidized or unreliable sensor connector
- Weak crimp of the terminal in the connector
- Degradation of the resistive element of the position sensor
- Vibration short in wiring harness
How to Fix
- Count errors and check data on the number of operations
- Inspect the sensor wiring harness along its entire length for abrasions and cracks.
- Push/pull the connector while the engine is running - check if the error is reproduced
- Clean and treat the connector contacts with a special compound
- Check the connector terminals for tightness
- If necessary, replace the sensor or repair the wiring harness
- Carry out a long test drive to confirm the fix
FAQ
Почему прерывистые ошибки сложнее диагностировать?
Потому что неисправность проявляется непостоянно — только при определённой температуре, вибрации или нагрузке. При статической проверке всё может быть в норме. Нужна динамическая диагностика в условиях, при которых ошибка появляется.
Стоит ли чинить прерывистую ошибку, если машина едет нормально?
Да, стоит. Прерывистые неисправности обычно усугубляются со временем и могут привести к постоянному отказу системы. Чем раньше найти причину, тем дешевле обойдётся ремонт.